3DREP、3DREPE型-REXROTH比例閥 力士樂Rexroth三通減壓閥3DREP6*

REXROTH比例閥產品特點

由油缸、閥體兩部分組成。而節流孔板和高壓調節閥設計為一體，閥門開關排泄流量和降壓由液壓缸行程控制。能任意調整排泄壓力及流量，安全，方便。

比例減壓閥:壓降從50兆帕至于1.6兆帕，可以調節排泄壓力。

REXROTH比例閥工作原理

導閥的開啟都是利用頂部的調節螺栓順時針方向擰動，使彈簧縮產生的彈力，使導閥膜片向下凹陷，作用在導閥連桿上的力，使之向下位移打開導閥。當導閥開啟后，上游進汽管段A腔的蒸汽通過α通道(供汽調節通道)，經過導閥進入導閥環形汽腔，由β通道直接送到下面的活塞汽缸上腔。在A腔蒸汽不斷的供給下，壓力持續升高，推動活塞下行打開主閥，這時蒸汽*從A腔流至B腔。當下游出口管段B腔負荷滿足的情況下，余多的蒸汽又使B腔內的壓力不斷升高。不斷升高的壓力通過γ通道(壓力感應通道)反饋到導閥膜片下腔，使導閥膜片向上突起，克服了上部調節彈簧的壓力，導閥被關小或關閉。從而，關小或關閉來自上游α通道的蒸汽源。當活塞汽缸上腔壓力下降時，在下面復位彈簧的作用下，主閥被關小或關閉，這時B腔內的壓力開始下降，這樣周而復始達到調壓的目的。

REXROTH比例閥安裝說明

1、在比例式減壓閥安裝前應將管道沖洗干凈并在閥前加裝 Y 型由于管道內細小的雜物都將會導致減壓閥關閉不嚴從而引起滲漏而失效導致閥后管網靜壓超高。 過濾器應設置在總管上并去掉堵頭引出裝有閥門的排水管至污水池以便及時排污。

2、比例式減壓閥前后必須設置閘閥或蝶閥以便檢修時切斷水源。

3、比例式減壓閥宜垂直安裝。 其安裝說明書上說可垂直安裝也可水平安裝但當水平安裝時由于重力作用會造成下部的偏心磨損因此宜垂直安裝并應按閥體上所示箭頭方向安裝。 江銀大廈消火栓給水自動噴淋系統比例式減壓閥均采用垂直安裝減壓效果明顯功能正常。

4、在高層建筑消防給水中為保證供水的不間斷性減壓閥組宜設計為兩組同徑并聯其中一組工作一組備用。 且應與前后管徑相同以便檢修更換時不影響供水。

5、消防給水系統中比例式減壓閥不宜設置旁通管。 在江銀大廈消火栓系統減壓閥施工中初期安裝了旁通管在使用約一年半后季檢時發現閥后壓力表與閥前壓力表數值相同打開試驗閥放水試驗測試壓力則又顯示正常而后檢查時發現是由于設于旁通管上的閥門膠襯老化導致滲漏而出現靜壓失常動、壓正常的現象。 所以為保證消防給水系統的供水可靠性，本人認為不應設置旁通管。

6、在比例式減壓閥前后宜裝設壓力表可直接用于觀察減壓閥前后壓力的變化監察減壓閥的減壓效果和工作情況。

7、在高層建筑消火栓系統的比例式減壓閥后一般宜設置可曲撓橡膠接頭。 一方面為便于減壓閥安裝拆卸同時亦可起到伸縮節作用。

3DREP、3DREPE型-REXROTH比例閥產品詳情力士樂Rexroth三通減壓閥3DREP6*

3DREP、3DREPE型三通比例減壓閥

3DREP/3DREPE型6通徑三通減壓閥由比例電磁鐵直接驅動，將輸入的電信號按比例地轉化成壓力輸出信號。比例電磁鐵是帶中心螺紋和可更換線圈的濕式可控直流電磁鐵，電磁鐵可通過外部電控器和集成電控器精細控制。該閥zui大工作壓力100 bar，zui大流量15 L/min。
特點：直控式比例閥用于壓力控制；由帶中心螺紋和可更換線圈的比例電磁鐵驅動；用于底板安裝；可選應急手動操控；控制閥芯彈簧對中。3DREPE型帶內置放大器，接口A1。3DREP、3DREPE型-REXROTH比例閥

R900343805   3DREP 6 A-1X/16A12NZ4M         

R900346607   3DREP 6 A-1X/25A24N9Z4M       

3DREP、3DREPE型-REXROTH比例閥       

R900350832   3DREP 6 C-1X/45A24NJM      

R900353001   3DREP 6 A-1X/16A12NK4M          

R900375358   3DREP 6 C-1X/16A24N9Z4M          

R900385415    3DREP 6 C-1X/25A24NJV      

R900388092   3DREP 6 C-1X/25A24N9Z4V        

R900408856   3DREP 6 C-1X/25A24NZ4M            

R900408857   3DREP 6 C-1X/25A24Z4M           

R900408859   3DREP 6 C-1X/25A24Z4V          

R900408860   3DREP 6 B-1X/25A24NZ4M          

R900408861    3DREP 6 B-1X/25A24Z4M          

R900408862   3DREP 6 B-1X/25A24NZ4V              

R900408863    3DREP 6 B-1X/25A24Z4V          

R900418492   3DREP 6 A-1X/25A24Z4M          

R900418493   3DREP 6 A-1X/25A24NZ4M           

R900444720   3DREP 6 C-1X/45A24N9Z4M             

R900451448   3DREP 6 A-1X/45A24N9K4M           

R900461243    3DREP 6 A-1X/45A24N9Z4M            

R900484840    3DREP 6 C-1X/16A24NJM            

R900487848   3DREP 6 C-1X/25A24N9Z4M         

R900494141   3DREP 6 C-1X/16A24Z4M         

R900494143  3DREP 6 C-1X/16A24NZ4M            

R900494145   3DREP 6 B-1X/16A24Z4M         

R900494149   3DREP 6 A-1X/16A24Z4M            

R900494151    3DREP 6 A-1X/16A24NZ4M         

R900494153   3DREP 6 C-1X/16A24K4M         

R900494155   3DREP 6 C-1X/16A24NK4M           

R900494159   3DREP 6 B-1X/16A24NK4M         

R900494162   3DREP 6 A-1X/16A24NK4V         

R900494163    3DREP 6 A-1X/16A24NK4M        

R900494165   3DREP 6 C-1X/25A24K4M          

R900494167   3DREP 6 C-1X/25A24NK4M         

R900494169   3DREP 6 B-1X/25A24K4M        

R900494170    3DREP 6 B-1X/25A24NK4V        

R900494171   3DREP 6 B-1X/25A24NK4M           

R900494174   3DREP 6 A-1X/25A24NK4V            

R900494175   3DREP 6 A-1X/25A24NK4M    

R900494177   3DREP 6 C-1X/45A24Z4M        

R900494178    3DREP 6 C-1X/45A24NZ4V          

R900494179   3DREP 6 C-1X/45A24NZ4M      

R900494181    3DREP 6 B-1X/45A24Z4M          

R900494182    3DREP 6 B-1X/45A24NZ4V          

R900494183    3DREP 6 B-1X/45A24NZ4M         

R900494184   3DREP 6 A-1X/45A24Z4V            

R900494185   3DREP 6 A-1X/45A24Z4M            

R900494187    3DREP 6 A-1X/45A24NZ4M         

R900494189    3DREP 6 C-1X/45A24K4M           

R900498481    3DREP 6 C-1X/25A12NZ4M           

R900498485   3DREP 6 C-1X/25A12NK4M           

R900498672  3DREP 6 C-1X/25A24JM          

R900498675   3DREP 6 B-1X/25A24NJM          

R900498677   3DREP 6 A-1X/25A24NJM            

R900522423    3DREP 6 C-1X/25A24NJV-10          

R900547100   3DREP 6 C-1X/25A24N9K4M              

R900550096   3DREP 6 C-1X/16A24N9K4M              

R900551330   3DREP 6 C-1X/25A24NK4V            

R900557601   3DREP 6 C-1X/25A24N1K10M             

R900558741   3DREP 6 A-1X=25A24NZ4M=LB         

R900558742   3DREP 6 B-1X=45A24NZ4M=LB           

R900559440    3DREP 6 C-1X=25A24NZ4M=LB     

R900560615    3DREP 6 B-1X/45A24NJM         

R900563134   3DREP 6 A-1X/25A24N9Z4V          

R900573750   3DREP 6 C-1X/25A24N9K4V           

R900576424    3DREP 6 C-1X/25A24N2JK10M            

R900579399   3DREP 6 A-1X=45A24NZ4M=LB            

R900580022   3DREP 6 B-1X/45A24N9Z4M            

R900589564   3DREP 6 C-1X/16A24N9Z4V            

R900608423   3DREP 6 A-2X=45EG24N9K4/ML=00            

R900617936  3DREP 6 A-2X/45EG24N9K4/ML          

R900700514   3DREPE 6 C-2X=16EG24N9K31/F1V=00         

R900700593   3DREPE 6 C-2X/16EG24N9K31/A1V           

R900706205   3DREPE 6 C-2X/45EG24N9K31/A1M            

R900706435   3DREPEB 6 A-2X/25EG24N9K31/A1V            

R900707910   3DREP 6 A-1X/25A24N9K4V            

R900708622   3DREPEB 6 A-2X=25EG24N9K31/A1V=00           

R900713629    3DREP 6 B-2X/45EG24N9K4/M           

R900714944    3DREP 6 A-2X=16EG24K4/V=00             

R900717553   3DREPE 6 A-2X/45EG24K31/A1V       

R900717554  3DREPE 6 A-2X=45EG24K31/A1V=00            

R900717941   3DREP 6 B-2X=45EG24N9K4/M=00       

R900717942    3DREPE 6 C-2X=16EG24N9K31/A1V=00           

R900718718   3DREP 6 B-1X/25A24N9K4V         

R900728553    3DREP 6 B-2X/45EG24K4/M            

R900728554   3DREP 6 B-2X=45EG24K4/M=00           

R900735026    3DREP 6 C-2X/25EG24JD/M        

R900736943    3DREP 6 A-1X/16A24K4M           

R900737480   3DREP 6 C-2X=25EG24JD/M=00           

R900747117   3DREP 6 A-1X/16A24N9K4M             

R900753106   3DREP 6 C-2X/25EG24N6K4/M           

R900753107   3DREP 6 C-2X=25EG24N6K4/M=00       

R900754062   3DREP 6 C-2X/25EG24N9K4/M=PL          

R900754960   3DREP 6 C-2X/25EG24N5K4/M          

R900754961   3DREP 6 C-2X=25EG24N5K4/M=00           

R900755111   3DREP 6 C-2X/25EG24N9K4/M-20           

R900755114   3DREP 6 C-2X/25EG24K4/M-20          

R900755122   3DREP 6 C-2X=25EG24N9K4/M-20=00          

R900755123   3DREP 6 C-2X=25EG24K4/M-20=00           

R900766916   3DREPE 6 C-2X=25EG24NJK31/A1M =00            

R900766917   3DREPE 6 C-2X/25EG24NJK31/A1M            

R900769054   3DREP 6 C-2X=25EG24N9K4/M-20=PL         

R900777525   3DREP 6 C-1X/45A12NK4M            

R900780118    3DREP 6 B-2X=25EG24K4/V=00            

R900782219   3DREPE 6 C-2X/16EG24N9K31/F1M            

R900782220   3DREPE 6 C-2X=16EG24N9K31/F1M=00             

R900785794    3DREPE 6 C-2X/45EG24NJK31/A1M         

R900912233   3DREP 6 C-1X/45A24N9Z4V          

R900917218   3DREP 6 B-1X/25A24N9K4M           

R900925013    3DREPE 6 B-2X/45EG24N9K31/A1V            

R900925484    3DREPE 6 C-2X/25EG24N9K31/A1V           

R900925526   3DREPE 6 A-2X/25EG24N9K31/A1V            

R900925527   3DREPE 6 C-2X/25EG24K31/A1V            

R900925707   3DREPEB 6 C-2X/25EG24N9K31/A1V           

R900926631   3DREP 6 A-1X/25A24N9K4M            

R900926984   3DREPE 6 C-2X/25EG24N9K31/F1V          

R900928547   3DREPEB 6 C-2X/25EG24K31/A1V            

R900929529   3DREP 6 C-2X/25EG24N9K4/V            

R900929865    3DREPE 6 B-2X/45EG24N9K31/A1V=LB          

R900930254    3DREPEB 6 C-2X=25EG24K31/A1V=00           

R900930255   3DREPEB 6 C-2X=25EG24N9K31/A1V=00           

R900930256   3DREPEB 6 C-2X=25EG24N9K31/F1V=00         

R900930257   3DREPE 6 A-2X=25EG24N9K31/A1V=00            

R900930259   3DREPE 6 B-2X=45EG24N9K31/A1V=00         

R900930263   3DREPE 6 C-2X=25EG24K31/A1V=00          

R900930264   3DREPE 6 C-2X=25EG24N9K31/A1V=00        

R900930265   3DREPE 6 C-2X=25EG24N9K31/F1V=00          

R900930267   3DREP 6 C-2X=25EG24N9K4/V=00         

R900930539   3DREP 6 B-2X=25EG24N9K4/V-628=00           

R900931050    3DREPE 6 B-2X/25EG24N9K31/A1V          

R900932154   3DREP 6 C-2X/25EG24K4/V       

R900932157   3DREPE 6 B-2X=25EG24N9K31/A1V=00         

R900934398   3DREP 6 A-1X/25A24K4M            

R900935218    3DREP 6 C-2X=25EG24K4/V=00           

R900938345    3DREPE 6 C-2X=25EG24N9K31/A1V=LB          

R900939656   3DREP 6 C-1X/25A24K4V         

R900940445   3DREP 6 B-1X/25A12NK4M          

R900943289   3DREPE 6 A-2X/45EG24N9K31/A1V            

R900943943    3DREPE 6 B-2X/25EG24N9K31/F1V           

R900944177    3DREPE 6 A-2X=45EG24N9K31/A1V=00          

R900944231   3DREP 6 C-2X/16EG24N9K4/V          

R900944232   3DREP 6 C-2X=16EG24N9K4/V=00          

R900944584    3DREPE 6 B-2X=25EG24N9K31/F1V=00           

R900945017   3DREP 6 C-2X/16EG24N9K4/V-6       

R900945018   3DREP 6 C-2X=16EG24N9K4/V-6=00           

R900945686    3DREP 6 A-2X/25EG24K4/V            

R900945801    3DREP 6 A-2X/25EG24N9K4/V            

R900945828   3DREP 6 C-2X=25EG24N9K4/V-589=00           

R900945836   3DREP 6 A-2X=25EG24K4/V=00           

R900945993    3DREP 6 B-1X/16A24N9K4M           

R900947444    3DREP 6 C-2X/45EG24N9K4/V           

R900947445    3DREP 6 C-2X=45EG24N9K4/V=00            

R900947955    3DREP 6 B-2X/25EG24N9K4/V             

R900947956   3DREP 6 B-2X=25EG24N9K4/V=00            

R900947957    3DREPEB 6 B-2X/25EG24N9K31/A1V            

R900948409   3DREPE 6 C-2X/25EG24NJK31/F1V         

R900948830   3DREPE 6 C-2X=25EG24NJK31/F1V =00          

R900949625   3DREP 6 A-2X=25EG24N9K4/V=00           

R900950265   3DREPEB 6 B-2X=25EG24N9K31/A1V=00         

R900950505   3DREP 6 A-1X/45A24K4M           

R900950904   3DREP 6 C-2X=25EG24K4/V-589=00          

R900951803    3DREP 6 A-1X/25A24K4V         

R900952507   3DREP 6 C-1X/16A24K4V          

R900952836   3DREP 6 C-1X/16A24NK4V           

R900954111   3DREPEB 6 C-2X/45EG24N9K31/A1V         

R900954411   3DREP 6 A-2X/16EG24K4/V            

R900954417   3DREP 6 A-2X/25EG24K4/M           

R900954418   3DREP 6 A-2X/45EG24K4/M          

R900954419   3DREP 6 C-2X/16EG24K4/M         

R900954420   3DREP 6 C-2X/25EG24K4/M         

R900954421   3DREP 6 C-2X/45EG24K4/M          

R900954422   3DREPE 6 A-2X/16EG24K31/A1M         

R900954423   3DREPE 6 A-2X/25EG24K31/A1M          

R900954424   3DREPE 6 A-2X/45EG24K31/A1M          

R900954425   3DREPE 6 C-2X/16EG24K31/A1M          

R900954427   3DREPE 6 C-2X/25EG24K31/A1M            

R900954428   3DREPE 6 C-2X/45EG24K31/A1M          

R900954474   3DREP 6 A-2X/16EG24K4/M            

R900954485    3DREPE 6 A-2X=16EG24K31/A1M=00           

R900954486    3DREPE 6 A-2X=25EG24K31/A1M=00             

R900954487   3DREPE 6 A-2X=45EG24K31/A1M=00            

R900954488    3DREPE 6 C-2X=16EG24K31/A1M=00            

R900954489   3DREPE 6 C-2X=25EG24K31/A1M=00             

R900954490   3DREPE 6 C-2X=45EG24K31/A1M=00           

R900954491   3DREP 6 A-2X=16EG24K4/M=00         

R900954492    3DREP 6 A-2X=25EG24N9K4/M=00           

R900954493   3DREP 6 A-2X=45EG24K4/M=00            

R900954494   3DREP 6 C-2X=16EG24K4/M=00            

R900954495   3DREP 6 C-2X=25EG24K4/M=00          

R900954496   3DREP 6 C-2X=45EG24K4/M=00           

R900954828   3DREP 6 A-1X/45A12NK4M             

R900955415   3DREPEB 6 A-2X/45EG24K31/A1V          

R900955444    3DREPEB 6 C-2X=45EG24N9K31/A1V=00           

R900955469   3DREP 6 C-1X/25A24NK4V-5           

R900955784   3DREPE 6 C-2X/25EG24N9K31/A1M          

R900955796    3DREP 6 C-2X/45EG24N9K4/M           

R900955803   3DREP 6 A-2X/25EG24N9K4/M         

R900955853    3DREPE 6 C-2X/25EG24K31/F1V          

R900955862   3DREPE 6 B-2X/25EG24N9K31/A1M        

R900955887   3DREP 6 C-2X/25EG24N9K4/M         

R900956100   3DREP 6 C-2X/16EG24N9K4/M            

R900956101   3DREP 6 C-2X=25EG24N9K4/M=00           

R900956182   3DREPE 6 B-2X/25EG24K31/A1M         

R900956355   3DREPEB 6 A-2X=45EG24K31/A1V=00         

R900956636   3DREP 6 B-2X/25EG24N9K4/M            

R900956637   3DREP 6 B-2X=25EG24N9K4/M=00         

R900956684   3DREPE 6 C-2X=25EG24K31/F1V=00        

R900957026   3DREP 6 C-1X/16A24NK4M-6        

R900958036    3DREP 6 C-2X=45EG24N9K4/M=00            

R900958788   3DREPE 6 C-2X=25EG24N9K31/A1M=00          

R900958848   3DREPE 6 C-2X/25EG24N9K31/F1M           

R900958859   3DREPE 6 C-2X=25EG24N9K31/F1M=00